SURREY FIRE SAFETY HOUSE
Model # 36BHS1
Bleacher Seating - Home Style Decor
SEE LOWERSECTION OF SPECS FOR ALUMINUM SKIN UNIT
SPECIFICATION SHEET
LENGTH: 36' 6" WIDTH: 8'0" GVW: 6,400# GVWR: 10,400#
HEIGHT: 11' 6" Interior Ht.: 90" HITCH WT.: 800# AXLE WT.: 5,600#
ADA Compliant: All units handicap accessible.
FRAME & SIDEWALL CONSTRUCTION
FRAME 2X8 high strength Bull MooseŽ double tube steel rails. Welded battery rack on tongue with a steel tube 4x4 rear bumper with aluminum cover and standard safety chains. Rear skid bars for additional protection.
SIDEWALL CONSTRUCTION
2x3 members 16" on center. Studs are bonded to 5/32 plywood paneling for high strength and lightweight. ABS fenders with galvanized wheel pans. Hand cut fiberglass insulation in sidewalls with a R 7 rating.
EXTERIOR: The exterior of the house is white vinyl siding with a lifetime guarantee, black shutters and commercial simulated cedar shakes on the mansard roof.
AXLES AND BRAKES
Unit shall have tandem rubber torsion axles rated at 5,200 lb. each. The axles are spring leaf. 4 wheel 12 " electric brakes will be utilized mfg by Hayes or equal. A brake away switch will be attached to the frame as an emergency stop, in the unlikely event of unit separation.
TIRES AND WHEELS: ST225/75/R15 trailer tires on heavy duty styled white 6 lug wheels and center caps.
LIGHTS-INTERIOR: 12-volt fluorescent lights shall be ceiling mounted, dome lights will be in all other areas such as control room and in compartments etc as follows, total of 25 lights. (some have 2 lights in one fixture): Bedroom-6, Storage compartment-1, Bay window-1,
Control room-2, Kitchen-5, Living room-6, (inc. 2 over elec. fireplace)
LIGHTS-EXTERIOR:2 porch lights. 1 on door side and one on rear. The lights are 110-volt fixture with the ability to flash a distress signal to responding assistance. A light fixture is provided in the top of the generator storage compartment. Standard ICC lights are in place as required. 2 hook up lights are on the power tongue jack. A 12 volt power source with an on/off switch is prewired to the roof for a strobe or rotator. The wall switch will be located in the control room. (4) lights are at steps.
ROOF A 1 piece rubber roof is provided over a 7/16 OSB underlayment Tapered 2x6 roof truss system provides a crown to the roof eliminating puddling. 4 roof vents are in place.
FLOOR: The floor is constructed of 5/8" exterior grade tongue & groove plywood on 2x4 support
members 12" on center. Living room, bedroom and stairs are fully carpeted with a ˝" rebond pad. Kitchen and control room as well as the storage compartments have a fully insulated floor with heavy-duty vinyl under belly for maximum weather shielding at a minimal weight.
WINDOWS
All windows are heat-treated safety glass. Shutters are provided on all side and front windows. A single hung 36"x 36" control room picture window with screen and mini blind is provided. Living room and bedroom windows are vinyl residential, with insulated glass. Curtains, with tiebacks, and valances with the exception of the 40"x 45" sliding window leading onto the escape ladder.
FIREPLACE
An electric fireplace with crackling sounds will be located in the living room. It will have a screen and simulated brick face. An on/off switch will be wall mounted next to the fireplace.
REAR LADDER: A commercially available chain escape ladder shall be bolted securely for escape simulation. The ladder will be mounted in a manner that allows shoe clearance between siding and chain ladder.
KITCHEN
The kitchen shall be equipped with a functional 3-burner stove with oven. The stove will be equipped with a shut off valve in the gas supply line. A city water hook up is provided to allow use of the double stainless steel sink. A functional microwave oven will be provided as well as a place for a refrigerator with 4 power outlets. An exhaust fan and hood with light will also be provided. Upper and lower cabinets are in place. There are two carpeted benches provided.
FRONT ROOM-carpeted bleacher seats shall be provided for students
SMOKE MACHINE AND FLUID
Smoke machine and 1 case of water base smoke fluid is standard. MSDS sheet provided.
CONTROL ROOM
A control room will be provided allowing control of many educational functions. A hands free 911-phone system for 911 training. On/off switch for 110 volt smoke alarms. An on/off switch for bedroom electrically heated door shall be in the control room. ABS smoke ducting system (schedule 40) with control valves allowing room selection as well as an operating location and outlet for water base smoke machine. A smoke ready light in the control room will be controlled by the training officer in the bedroom. The control room will have a 48" counter with storage cabinets and a 48" x 15.5"x 23" cushion on a bench for the control room operator. A 3'x3' single hung window with screen and mini blind. Observation ports in bedroom & living room. A power vent is also provided.
GENERATOR STORAGE A generator compartment is provided to store and transport a generator. It is located so that the wheel chair ramp can be used to load and unload generator.
TV CABINET: A TV cabinet and slide-out shelf is provided on the awning side of the unit.
A slide out shelf will be in place. This allows the tv position to be adjusted to accommodate changing light conditions
DOORS-OUTSIDE:
(2) 36"x 75" out swinging residential door is provided on the curbside. A 7"x55" door with key lock will be on left side for handicap ramp storage compartment as well as a 40"x11" door with key lock for under bed storage access.
COOLING, HEATING AND VENTILATION
13,500 BTU air conditioning is standard, with ducting to bedroom, living room, control room and kitchen. Heat will be provided by a 35,000 BTU Atwood #8500 forced air furnace ducted throughout. 4 power roof vents shall be installed to aid in removing non toxic smoke as well as help hold the smoke to the ceiling during training.
BEDROOM
The bedroom shall be on the main floor. It will be fully carpeted with rebond pad, curtains with tiebacks valances and mini blinds on the single hung windows. A bed with vinyl covered mattress, bedspread and pillow sham. A carpeted bench is included. An exhaust fan shall be roof mounted with an on/off switch control, allowing instructor to monitor smoke removal. A smoke on signal in the control room can be activated by the instructor in the bedroom A sliding window in the rear of the unit will allow access to rear escape ladder. An electrically heated door is used to simulate fire on the opposite side.
ELECTRICAL-110 VOLT:
A 30-amp power supply cord shall be provided for 110-volt AC power needs. All wall receptacles are functional. Ground fault receptacles are in the kitchen as well as both outside outlets. Power is supplied through circuit breakers built into a 55 amp DC solid-state power converter.
ELECTRICAL-12 VOLT:12-volt power for the unit is provided by a 55-amp solid-state power converter mfg by Elixir or equal.. The converter will supply all 12-volt needs of the unit when plugged in. The unit will have a deep cycle battery and box to supply 12 volt power on short term when not plugged in.
BATTERY CUT OFF
A switch is provided to shut the battery down for storage. This eliminates a dead battery from accidentally leaving on a light during storage. Your battery will be charged and ready to go.
BACK UP BEEPER
An audible tone will be heard at the rear of the safety house warning any one in the area that the unit is moving in reverse. (The tow vehicle must be properly wired to activate this alarm)
911 PHONE With Call back feature:
A wall phone will be located in the living room allowing a child to experience dialing 911 or any number and reaching (control room) a fire fighter or dispatcher. The system is hands free for the control room operator. An external phone jack will be located on the door side of the unit, allowing 911 training from outside the unit or to demonstrate the need to exit the home in a fire situation and call from a neighbor.
HITCH JACK
A 12-volt power tongue jack manufactured by Barker Mfg. will be in place. The unit will have manual back up capability as well as a hookup light.
STABILIZER JACK
4 BAL or equal, crank down stabilizer jacks shall be frame mounted. These jacks will stabilize the unit and eliminate suspension travel while occupied.
AWNING
A 21 ft roll up awning shall be in place on the curb side of the unit. The awning shall cover the main entrance door.
OUTLETS
Control room-5, Kitchen-4, Living room-3, Bedroom-4, Outside-2.
Due to the constant refinement and development of the Safety House the specifications may change with out notice
Effective 07/01/03
SURREY FIRE SAFETY HOUSE
Model #36BHS1-A
SPECIFICATION SHEET
Aluminum Exterior- Home Style
LENGTH: 36' 6" WIDTH: 8'0" GVW: 6,400# GVWR: 10,400#
HEIGHT: 11' 6" Interior Ht.: 90" HITCH WT.: 800# AXLE WT.: 5,600#
ADA Compliant: All units handicap accessible.
FRAME & SIDEWALL CONSTRUCTION
FRAME 2X8 high strength Bullmoose double tube steel rails. Welded battery rack on tongue with a steel tube 4x4 rear bumper with aluminum cover and standard safety chains. Rear skid bars for additional protection.
SIDEWALL CONSTRUCTION
2x3 members 16" on center. Studs are bonded to 5/32 plywood paneling for high strength and lightweight. ABS fenders with galvanized wheel pans. Handcut fiberglass insulation in sidewalls with a
R 7 rating.
EXTERIOR: The exterior of the house is white aluminum RV siding with black shutters
AXLES AND BRAKES
Unit shall have tandem rubber torsion axles rated at 5,200 lb. each. The axles are spring leaf. 4 wheel 12 " electric brakes will be utilized mfg by Hayes or equal. A brake away switch will be attached to the frame as an emergency stop, in the unlikely event of unit separation.
TIRES AND WHEELS: ST225/75/R15 trailer tires on heavy duty styled white 6 lug wheels and center caps.
LIGHTS-INTERIOR: 12-volt fluorescent lights shall be ceiling mounted, dome lights will be in all other areas such as control room and in compartments etc as follows, total of 25 lights. (some have 2 lights in one fixture): Bedroom-6, Storage compartment-1, Bay window-1, Control room-2, Kitchen-5, Living room-6, (inc. 2 over elec. fireplace)
LIGHTS-EXTERIOR:2 porch lights. 1 on door side and one on rear. The lights are 110-volt fixture with the ability to flash a distress signal to responding assistance. A light fixture is provided in the top of the generator storage compartment. Standard ICC lights are in place as required. A hook up light is on the power tongue jack. A 12 volt power source with an on/off switch is prewired to the roof for a strobe light . The wall switch will be located in the control room. (4) lights are at steps.
ROOF A 1 piece TPO (Thermal Poly Olyhan) roof is provided over a 7/16 OSB underlayment Tapered 2x6 roof truss system provides a crown to the roof eliminating puddling. 4 roof vents are in place.
FLOOR: The floor is constructed of 5/8" exterior grade tongue & groove plywood on 2x4 support
members 12" on center. Living room, bedroom and stairs are fully carpeted with a ˝" rebond pad. Kitchen and control room as well as the storage compartments have a fully insulated floor with heavy-duty vinyl under belly for maximum weather shielding at a minimal weight.
WINDOWS
All windows are vinyl residential with heat-treated safety glass A single hung 36"x 36" control room picture window with screen and mini blind is provided. Living room and bedroom windows are vinyl residential type with tip out feature for cleaning. Curtains, with tiebacks, and valances with the exception of the 40"x 45" sliding window leading onto the escape ladder and control room window.
FIREPLACE An electric fireplace with crackling sounds will be located in the living room. It will have a screen and simulated brick face. An on/off switch will be wall mounted next to the fireplace.
REAR LADDER:
A commercially available chain escape ladder shall be bolted securely for escape simulation. The ladder will be mounted in a manner that allows shoe clearance between siding and chain ladder.
KITCHEN
The kitchen shall be equipped with a functional 3-burner stove with oven. The stove will be equipped with a shut off valve in the gas supply line. A city water hook up is provided to allow use of stainless steel sink. A functional microwave oven will be provided as well as a place for a refrigerator with 4 power outlets. An exhaust fan and hood with light will also be provided. Upper and lower cabinets are in place. There are two carpeted benches provided.
FRONT ROOM-carpeted bleacher seats shall be provided.
SMOKE MACHINE AND FLUID
Smoke machine and 1 case of water base smoke fluid is standard. MSDS sheet provided.
CONTROL ROOM
A control room will be provided allowing control of many educational functions. A hands free 911-phone system for 911 training. On/off switch for 110 volt smoke alarms. An on/off switch for bedroom electrically heated door shall be in the control room. ABS smoke ducting system (schedule 40) with control valves allowing room selection as well as an operating location and outlet for water base smoke machine. A smoke ready light in the control room will be controlled by the training officer in the bedroom. The control room will have a 48" counter with storage cabinets and a 48" x 15.5"x 23" cushion on a bench for the control room operator. A 3'x3' single hung window with screen and mini blind. Observation ports in bedroom & living room. A power vent is also provided.
GENERATOR STORAGE A generator compartment is provided to store and transport a generator. It is located so that the wheel chair ramp can be used to load and unload generator.
TV CABINET: A TV cabinet and slide-out shelf is provided on the awning side of the unit.
A slide out shelf will be in place. This allows the tv position to be adjusted to accommodate changing light conditions
DOORS-OUTSIDE
(2) 36"x 75" out swinging residential door is provided on the curbside. A 7"x55" door with key lock will be on left side for handicap ramp storage compartment as well as a 40"x11" door with key lock for under bed storage access.
COOLING, HEATING AND VENTILATION
13,500 BTU air conditioning is standard, with ducting to bedroom, living room, control room and kitchen. Heat will be provided by a 35,000 BTU Atwood #8500 forced air furnace ducted throughout. 4 power roof vents shall be installed to aid in removing non toxic smoke as well as help hold the smoke to the ceiling during training.
BEDROOM
The bedroom shall be on the main floor. It will be fully carpeted with rebond pad, curtains with tiebacks valances and mini blinds on the single hung windows. A bed with vinyl covered mattress, bedspread and pillow sham. A carpeted bench is included. An exhaust fan shall be roof mounted with an on/off switch control, allowing instructor to monitor smoke removal. A smoke on signal in the control room can be activated by the instructor in the bedroom A sliding window in the rear of the unit will allow access to rear escape ladder. An electrically heated door is used to simulate fire on the opposite side.
ELECTRICAL-110 VOLT:
A 30-amp power supply cord shall be provided for 110-volt AC power needs. All wall receptacles are functional. Ground fault receptacles are in the kitchen as well as both outside outlets. Power is supplied through circuit breakers built into a 55 amp DC solid-state power converter.
ELECTRICAL-12 VOLT:12-volt power for the unit is provided by a 55-amp magnetek solid-state power converter. The converter will supply all 12-volt needs of the unit when plugged in. The unit will have a deep cycle battery and box to supply 12 volt power on short term when not plugged in.
ELECTRICAL-12 VOLT:12-volt power for the unit is provided by a 55-amp solid-state power converter mfg by Elixir or equal.. The converter will supply all 12-volt needs of the unit when plugged in. The unit will have a deep cycle battery and box to supply 12 volt power on short term when not plugged in.
BATTERY CUT OFF
A switch is provided to shut the battery down for storage. This eliminates a dead battery from accidentally leaving on a light during storage. Your battery will be charged and ready to go.
BACK UP BEEPER
An audible tone will be heard at the rear of the safety house warning any one in the area that the unit is moving in reverse. (The tow vehicle must be properly wired to activate this alarm)
911 PHONE With Call Back Feature:
A wall phone will be located in the living room allowing a child to experience dialing 911 or any number and reaching (control room) a fire fighter or dispatcher. The system is hands free for the control room operator. An external phone jack will be located on the door side of the unit, allowing 911 training from outside the unit or to demonstrate the need to exit the home in a fire situation and call from a neighbor.
HITCH JACK
A 12-volt power tongue jack manufactured by Barker Mfg. will be in place. The unit will have manual back up capability as well as a hookup light.
STABILIZER JACK
4 BAL or equal, crank down stabilizer jacks shall be frame mounted. These jacks will stabilize the unit and eliminate suspension travel while occupied.
AWNING
A 21 ft deluxe roll out awning shall be in place on the door side of the unit
OUTLETS
Control room-5, Kitchen-4, Living room-3, Bedroom-4, Outside-2.