SURREY FIRE SAFETY HOUSE
#29LTD2 29 FT. 2 LEVEL Fiberglass Exterior
SPECIFICATION SHEET
LENGTH: 29'4" WIDTH: 8'0" HITCH BALL HEIGHT: 18" AXLE WT:4,800#
HEIGHT: 11'8" Int. 105” GVWR. 7,000 # HITCH WT.: 685# GVW: 5,553#
ADA Compliant: All units handicap accessible.
FRAME & SIDEWALL CONSTRUCTION:
FRAME 2X6 high strength 3/16” tubular steel. Welded battery rack on tongue with a steel tube 4x4 rear bumper and standard safety chains and rear skid bars
SIDEWALL CONSTRUCTION:
Standard RV 2x3 and 2x2 RV construction. Bonded to 5/32 plywood paneling for high strength and lightweight. ABS fenders with galvanized wheel pans. Hand cut fiberglass insulation in side walls.
EXTERIOR: The exterior of the house is white in color and is heavy .Fiberglass offering a superior surface for graphics adhesion and lettering as well as maintenance free. All windows and doors are sealed to the body using (Clean Seal) not putty tape, offering the best water seal available today. A Lend-A-Hand folding assist grab handle shall be in place at the side entrance door. There will be a 18 ft. awning in place on the curb side.
AXLES AND BRAKES:
A height adjustable suspension shall be in place. Overall unit height and ground clearance may be adjusted with this type suspension. The unit shall have tandem 4" drop axles 3,500# each with equalized suspension. The axles are spring leaf. 4 wheel 10 " electric brakes will be utilized mfg by Hayes or equal. A brake away switch will be attached to the frame as an emergency stop, in the unlikely event of unit separation. The inner fender pans are galvanized.
TIRES AND WHEELS
Steel belted radial ST205x75R15 tire on white painted mod 5 lug wheels
ROOF A 1 piece Rubber Roof is provided over a 7/16 OSB underlayment Tapered 2x6 roof truss system provides a crown to the roof eliminating puddling. 4 roof vents are in place.
FLOOR: The floor is constructed of 5/8" HIP® “Huber Industrial Panels” on 2”x 4” support members 12" on center. HIP® flooring has a limited “5” year warranty The bedroom is fully carpeted with a ˝" re-bond pad. Kitchen and control room as well as the storage compartments have a fully insulated floor with heavy-duty vinyl under belly for maximum weather shielding at a minimal weight..
LIGHTS INTERIOR: All interior light shall be fluorescent
LIGHTS EXTERIOR:
. Standard ICC lights are in place as required. All Lights are state of the art LED technology. In addition to the standard lighting high intensity LED upper body brake light and turn signals are installed. This allows your brake and turn signal lights to be visible above a vehicle behind you.
3-12 volt porch lights. 2 on door side and 1 on rear with a common switch in the kitchen at the front door. A hook up light is on the power tongue jack. A 12 volt power source with an on off switch is pre-wired to the roof for a strobe, the wall switch will be located in the control room.
WINDOWS: All windows are Radius corner Hi-Line heat-treated safety glass , except the Control Room window and the escape window onto the rear deck, upper
1-40"x45" sliding bedroom window. Curtains and valances on all sliding windows and 36"x36" mini blind on control room window. Two observation ports from control room to living room and bedroom.
FIREPLACE An electric fireplace will be located in the living room. It will have a screen and simulated brick face, an on/off switch will be wall mounted next to the fireplace.
REAR DECK: Upper and lower rear deck shall be constructed of pressure treated lumber. Upper deck 52"x36". Lower deck 41.5"x 45". A commercially available chain escape ladder shall be bolted securely at upper and lower deck for escape simulation. The ladder will be mounted in a manner that allows shoe clearance between siding and ladder. Treads come installed with non-skid surface.
KITCHEN: The kitchen shall be equipped with a functional 3-burner stove with oven. The stove will be equipped with a shut off valve in the gas supply line. A city water hook up is provided to allow use of stainless steel sink. A functional microwave oven will be provided as well as a place for a refrigerator with power outlet. An exhaust fan and hood with light will also be provided. Upper and lower cabinets and 106" ceiling height.
CONTROL ROOM: A control room will be provided allowing control of many educational functions. A 911-phone system for 911 training. On/off switch for 110 volt smoke alarms. An on/off switch for bedroom electrically heated door shall be in the control room. ABS smoke ducting system (schedule 40) with control valves allowing room selection as well as an operating location and outlet for water base smoke machine. A smoke ready light in the control room will be controlled by the training officer in the bedroom. The control room will have a 48" counter with storage cabinets and a 48"x12"x5" cushion on a bench for control room operator comfort. A 3'x3' single hung window with screen and mini blind. A power vent will be installed.
DOORS -OUTSIDE: Two Radius Corner (Hi- Line)34" entrance doors with flush handles and dead bolt locks and screen doors will be provided. Both doors will be equipped with head bump pads. A 7"x55" door with key lock will be on left rear for handicap ramp storage compartment as well as a 40"x11" door with key lock for under stairwell storage.
COOLING, HEATING AND VENTILATION: There will be a 13,500 BTU ducted air conditioner. Heat will be provided by a 35,000 BTU Atwood #8500 forced air furnace ducted throughout. 3 power roof vents, 1 in kitchen and 2 in bedroom installed to aid in removing non-toxic smoke as well as help hold the smoke to the ceiling during training.
HANDICAP RAMP
There will be a telescoping wheel chair ramp provided. This ramp is aluminum.
BEDROOM: The bedroom shall be on the upper level with 51" ceiling height. It will be fully carpeted with rebond pad, curtains and valances on side windows. A bed with mattress, bedspread and pillow sham. A nightstand and carpeted bench. 2 exhaust fans shall be roof mounted with a wall switch for on/off control allowing the instructor to monitor smoke removal. A wall switch for on/off control of a smoke activation signal in the control room will be installed. A sliding window in the rear of the unit will allow access to upper rear deck and escape ladder.
ELECTRICAL-110 VOLT: A standard RV 25' single 30 amp power supply cord shall be provided for 110 volt AC power into the unit. All wall receptacles are functional. Ground fault receptacles are in the kitchen as well as both outside outlets. Power is supplied through circuit breakers in a power panel. This panel also contains the power converter producing 12-volt power needed.
ELECTRICAL-12VOLT: 12-volt power for the unit is provided by a 55-amp solid-state power converter by Elixir or equal. The converter will supply all 12-volt needs of the unit when plugged in. The unit will have a deep cycle battery and box to supply 12 volt power on short term when not plugged in.
BACK–UP BEEPER a back up beeper is in place. This devise will warn others that the unit is in motion in reverse. ( Your tow vehicle must be properly wired for this feature to function)
BATTERY CUT OFF There is a battery disconnect switch in place that allows all 12 volt power from the battery shut off for storage
911 PHONE With Call back feature:
A wall phone will be located in the living room allowing a child to experience dialing 911 or any number and reaching (control room) a fire fighter or dispatcher. The system has a telephone in the control room An external phone jack will be located on the door side of the unit, allowing 911 training from outside the unit or to demonstrate the need to exit the home in a fire situation and call from a neighbor.
GENERATOR COMPARTMENT A generator Storage compartment is provided
(up grades are available)
OUTSIDE TV CABINET A tv cabinet with outlets for outside viewing is an option
SLIDE OUT TV TRAY There is a slide out tv shelf in the compartment is an option.
HITCH JACK: A high torque 12-volt power tongue jack manufactured by H&H Engineering will be in place. The unit will have manual back up capability as well as 2 hookup lights.
STABILIZER JACK: 4 crank down stabilizer jacks shall be frame mounted. These jacks will stabilize the unit and eliminate suspension travel while occupied.
OUTLETS: Smoke room-5, Kitchen-3, Living room-3, Bedroom-4, Outside-2.
LIVING ROOM: Windows with curtains, electric fireplace with on/off switch, carpeted benches, lights above mantle and wall mounted telephone.
AWNING RAIL An awning rail is in place on the curb side of the unit. This will allow an 18 ft. roll out awning to be added.
Due to the constant refinement and development of the Safety House the specifications may change with out notice.
7 18 08